For some reason today while the ac was running the blower motor started sounding like a card in the spokes of a bicycle....the faster it spins, the louder it gets. Where is the blower motor at, and how hard is it to swap out? The sound is way to loud to live with for long. I've got a '00 bonneville with manual climate control.
Anyone tackle this job? From searching the posts it looks like a replacement can be gotten at autozone.
HVAC blower motor getting very loud...how to replace?
-
J Wikoff
- Administrator
- Posts: 17080
- Joined: Mon May 19, 2008 7:01 pm
- Year and Trim: 1992 SSE
2009 G8 GT - Location: Central Illinois
- Contact:
Re: HVAC blower motor getting very loud...how to replace?
It's the round thing on the firewall, right near the middle. I have a feeling the 00-05 has a tighter space, but on my 92, you pull the drain hose off the bottom, unhook the wiring, remove the bolts, and you have just enough room to pull it out between the firewall and rear valve cover.
WHITE WHINE - 1992 SSE Supercharged 236.26 ci (.040 Over) 15.090 at 90.2 MPH on old engine w/ slipping trans & melted O2 sensor - Gen 3 M62 and matching TB, Gen 2 Pully, Zillamotorsports Ported LIM, YT 1.72 Roller Rockers, SII FPR & Injectors, Hypertech Thermomaster chip w/ 160 Thermo, TransGo Shift Kit, Infinity/Pioneer Speakers & a 10" Alpine Type R Sub, all the watts, 140 amp Alternator, Ricepipe CAI w/ heatshield, Pilot Angel Eye Foglights, Clear Corners, '02 17" Chrome Bent 5's, Magnaflow F-Body Muffler and Hi-flo Cat, Ceramic Coated Ported Exhaust Manifolds, Fan Override, Monroe Reflex struts, red calipers
2009 G8 GT - Sport Red Metallic, loaded, SOLO Axlebacks, Rotofab Intake, Tuned, autodim mirror, removed intake manifold cover, HSV GTS triple gauge pod, two tone red-hot shifter and HSV SuperSport steering wheel, GXP rear sway bar and diffuser, 3.45 diff and various Camaro suspension bits, LED Taillights
-
Archon
- Resident Gearhead
- Posts: 8781
- Joined: Mon May 19, 2008 10:30 pm
- Year and Trim: 2014 Cadillac XTS Vsport.
- Location: Grand Rapids, Michigan
Re: HVAC blower motor getting very loud...how to replace?
The blower motor has been moved in the 2000+s. It's now inside on the passenger side. It's a bit tricky to remove as it has to be turned "just so" to get it in and out. Before replacing it, check to make sure that nothing has gotten sucked into the fan. Things seem to find their way in there. Open the hood, and on the passenger side by the cowl, remove the cover for the cabin air filter (and the filter if it has one) and look inside for any strange objects.
*Gone, but not forgotten* - Black 2000 SSEi, HIR Headlights, Angel Eyes fogs, 3rd brake light overlay, hi-flo cat, 180 degree thermostat, HS 1.9 rockers, LSx yellow springs, Intense FWI, PCM, shift kit, push rods, and 3.4 Pulley. ZZP Power Log.
Re: HVAC blower motor getting very loud...how to replace?
Before you go removing the blower motor try taking out the cabin air filter and looking down in there for any foreign objects. I had the same thing happen on my wife's 2000 Bonneville and it turned out to be a small piece of paper that had gotten in there.